SOLICITATION NOTICE
43 -- Compressors
- Notice Date
- 8/12/2005
- Notice Type
- Solicitation Notice
- NAICS
- 333999
— All Other Miscellaneous General Purpose Machinery Manufacturing
- Contracting Office
- Department of the Navy, Naval Sea Systems Command, Naval Experimental Diving Unit, 321 Bullfinch Road, Panama City, FL, 32407-7015
- ZIP Code
- 32407-7015
- Solicitation Number
- N0463A-05-Q-4200
- Response Due
- 9/10/2005
- Archive Date
- 9/25/2005
- Small Business Set-Aside
- Total Small Business
- Description
- The NAVY EXPERIMENTAL DIVING UNIT, Panama City, FL., intends to procure via Simplified Acquisition Procedures, removal and replacement of one existing MAKO Model 5436 high pressure air compressor packages at the Navy Experimental Diving Unit, Bldg. 300. EQUIPMENT: Provide one (1) MAKO Model 5436-75E3-BA Four Stage Water-cooled Compressor Package, 84.0 scfm, 1443 RPM, @ 5000 psig driven by a 75 hp-460v/60hz/3 phase ODP motor. This package shall be baseplate / skid mounted and ready for immediate installation. The flow rate as listed is based on ?fill charge rates?. The proposed system shall be provided with the following accessories: Inlet filter, Intercoolers & aftercooler, Interstage and final condensate separators, Interstage and final relief valves, V-belt drive with guard, Discharge check valve, Interstage & final air pressure gauges, Oil pressure gauge, Hourmeter, Emergency stop button, Power on switch with indicator light, Auto start/stop air pressure switch with indicator light (stop @ 4500 psig), Low oil pressure shutdown switch with warning light, High temperature shutdown switch with warning light, Low water flow shutdown switch with warning light, Automatic condensate drain system,Auto drain muffler/reservoir with hose (loose accessory), Magnetic starter and control transformer, Water control shutoff valve, Thermostatic control valve, Two dial thermometers, Water pressure gauge, INSTALLATION: Installation shall be provided as follows: 1. Remove existing MAKO compressor package. 2. The new compressor package shall be mounted and secured to existing concrete foundation per manufacturer?s specifications. 3. Fabricate and provide piping / fittings and materials required to ?tie-in? the compressor package to the existing pipe assemblies. 4. Fabricate and provide electrical wire / conduit and materials as required to ?tie-in? the compressor package to the existing electrical system. STARTUP / WARRANTY VALIDATION: 1. Provide compressor with startup and validate MAKO package warranty. 2. Run compressor package for a period of no less than two (2) hours at full load and pressure capacity. 3. Warranty validation and startup to be provided by an authorized MAKO service technician. 4. Provide technical review of compressor package for NEDU personnel. THIS AWARD SHALL BE UTILIZING SIMPLIFIED ACQUISITION PORCEDURES. Telephone request are unacceptable. Request may be e-mailed to louis.diehl@navy.mil ALLREQUIREMENTS ARE STATED ABOVE. NO SOLICITATION AVAILABLE. ALL QUOTATIONS SHALL BE RECEIVED BY E-MAIL ONLY.
- Place of Performance
- Address: 321 Bullfinch Road, Panama City, FL
- Zip Code: 32407
- Country: U.A.
- Zip Code: 32407
- Record
- SN00869632-W 20050814/050812212717 (fbodaily.com)
- Source
-
FedBizOpps.gov Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |