SOLICITATION NOTICE
W -- RENTAL OF MANLIFTS
- Notice Date
- 9/14/2002
- Notice Type
- Solicitation Notice
- Contracting Office
- Department of the Navy, Commander in Chief, Atlantic Fleet, Command Navy Region Northeast, Procurement Center - CNRNE Code N411P Box 500 Bldg 84/1, Groton, CT, 06349
- ZIP Code
- 06349
- Solicitation Number
- N49399-02-T-0162
- Point of Contact
- Carol Angelo, Contracting Specialist, Phone 860-694-3270, Fax 860-694-3964, - Carol Angelo, Contracting Specialist, Phone 860-694-3270, Fax 860-694-3964,
- E-Mail Address
-
angeloc@subasenlon.navy.mil, angeloc@subasenlon.navy.mil
- Description
- THIS IS A COMBINED SYNOPSIS/SOLICITATION FOR COMMERCIAL ITEMS PREPARED IN ACCORDANCE WITH THE INFORMATION IN FAR SUPBART 12.6 AS SUPPLEMENTED WITH THE ADDITIONAL INFORMATION INCLUDED IN THIS NOTICE. THIS ANNOUNCEMENT CONSTITUTES THE ONLY SOLICITATION; A WRITTEN SOLICITATION WILL NOT BE ISSUED. THE RFQ NUMBER IS N49399-02-T-0162 USING SIMPLIFIED ACQUISITION PROCEDURES FOR COMMERCIAL ITEMS. THIS SOLICITATION DOCUMENT INCORPORATES PROVISIONS AND CLAUSES IN EFFECT THROUGH FAR AND DFARS. IT IS THE CONTRACTORS RESPONSIBILITY TO BE FAMILIAR WITH THE APPLICABLE CLAUSES AND PROVISIONS. THE CLAUSES MAY BE ACCESSED IN FULL TEXT AT THESE ADDRESSES: WWW.ARNET.GOV AND WWW.ACQ.OSD.MIL. THIS IS AN UNRESTRICTED COMPETITIVE ACTION. THE COMMAND NAVY REGION NORTH EAST REQUESTS RESPONSES FROM QUALIFIED SOURCES CAPABVLE OF PROVIDING THE FOLLOWING: ITEM 0001 MANLIFTS SHALL CONFORM TO THE FOLLOWING REQUIREMENTS. DIESEL POWERED; 15 GALLON MINIMUM FUEL CAPACITY; ARTICULATING BOOM WITH ZERO DEGREE TAIL SWING; AUDIBLE TRAVEL WARNING SIGNALS ONLY; FOAM-FILLED TIRES; 60 FOOT MAXIMUM ACCEPTABLE WORKING; 45 MINIMUM ACCEPTABLE WORKING HEIGHT; 200 POUNDS MINIMUM REQUIRED PLATFORM CAPACITY; 500 POUNDS MAXIMUM REQUIRED PLATFORM CAPACITY; 26,000 POUNDS MAXIMUM ACCEPTABLE OVERALL WEIGHT; 8 FEET MINIMUM ACCEPTABLE WHEELBASE; 20 DEGREE (35%) MINIMUM ACCEPTABLE GRADE ABILITY; 1 MPH MINIMUM ACCEPTABLE SPEED; 3.6 MPH MAXIMUM ACCEPTABLE SPEED; 8 FEET MAXIMUM ACCEPTABLE INSIDE TURNING RADIUS; 14 FEET MAXIMUM ACCEPTABLE OUTSIDE TURNING RADIUS; 1 FOOT MINIMUM ACCEPTABLE GROUND CLEARANCE. EQUIPMENT WILL BE USED FOR MULTIPLE SHIFTS PER DAY AND FOR SOME HYDRO BLASTING. ON-CALL MAINTENANCE IS REQUIRED FOR EACH MANLIFT. THIS MAINTENANCE SHALL PROVIDE AN 8-HOUR RESPONSE TIME TO TROUBLE CALLS AND A REPLACEMENT MANLIFT, IF MANLIFT WILL NOT BE FUNCTIONING AND AVAILABLE FOR USE WITHIN 24 HOURS OF TROUBLE CALL. MANLIFTS ARE TO BE DELIVERED TO AND PICKED UP AT NRMD LOWER BASE, NAVAL SUBMARINE BASE, GROTON, CT. TEST CERTIFICATION REQUIREMENTS FOR RENTAL ELEVATING EXTENDABLE BOOM PERSONNEL LIFTS-STATIC TEST AT 150% OF RATED CAPACITY ON LEVEL GROUND WITH BOOM AT OR NEAR MINIMUM EXTENSION ATTACH TEST WEIGHT TO THE BASKET SUCH TAT THE WEIGHT WILL BE SUSPENDED 6INCHES TO 8INCHES OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. USING THE GROUND CONTROLS, RAISE THE BOOM TO HORIZONTAL (STILL AT A MINIMUM EXTENSION). EXTEND BOOM TO MAXIMUM LENGTH. HOLD 10 MINUTES. ROTATE THE BOOM AND TEST WEIGHT 360 DEGREES, OR AS MUCH AS POSSIBLE. LOWER THE WEIGHT. DRIFT TEST AT 150% OF RATED CAPACITY ON LEVEL GROUND WITH THE BOOM AT OR NEAR MINIMUM EXTENSION, ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6INCHES TO 8INCHES OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. USING THE GROUND CONTROLS, RAISE THE BOOM TO HORIZONTAL (STILL AT MINIMUM EXTENSION). MEASURE AND RECORD THE BASKET (OR LOAD) VERTICAL HEIGHT AT 0, 10, AND 20 MINUTE INTERVALS. MEASURE VERTICAL DRIFT TO THE NEAREST 1/8INCH. MARK AND MEASURE RETRACTION OF BOOM LIFT CYLINDER TO THE NEAREST 1/16INCH TO DETERMINE IF RADIAL MOVEMENT OF LOAD WOULD EXIST. VERTICAL DRIFT SHALL NOT EXCEED ONE AND A HALF INCHES BETWEEN THE 10 AND 20 MINUTE INTERVALS. LOWER TEST WEIGHT TO GROUND. BOOM TEST AT 150% OF RATED CAPACITY. ON LEVEL GROUND WITH BOOM AT OR NEAR MINIMUM EXTENSION, ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6INCHES TO 8INCHES OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. USING THE GROUND CONTROLS, RAISE THE BOOM TO HORIZONTAL (STILL AT MINIMUM EXTENSION). EXTEND BOOM TO ITS MAXIMUM LENGTH. BOOM UP TO REDUCE THE RADIUS BY FIVE (5) FEET. TELESCOPE IN TO REDUCE BOOM LENGTH BY TEN FEET. LOWER LOAD TO THE GROUND. EMERGENCY POWER SYSTEM TEST AT 100% OF RATED CAPACITY. ON LEVEL GROUND WITH BOOM AT OR NEAR MINIMUM EXTENSION, ATTACH TEST WEIGHT TO THE BASKET SUCH THAT THE WEIGHT WILL BE SUSPENDED 6INCHES TO 8INCHES OFF THE GROUND WHEN THE BOOM IS HORIZONTAL. TEST WEIGHTS MAY BE PLACED IN THE BASKET AT THE CONTRACTORS CHOICE. EXTEND THE BOOM ONE QUARTER INCH MAXIMUM LENGTH. SHUT OFF MAIN ENGINE. SWITCH OVER TO EMERGENCY SYSTEM AND DEMONSTRATE THE MACHINES ABILITY TO GO TO A SAFE CONDITION. 5 DEGREE MULTI-AXIS SLOPE SENSOR AND WARNING LIGHT TEST WITH ZERO TEST WEIGHT LOAD. HAVE A MECHANIC OPEN THE CONTROL BOX LOCATED INSIDE ENGINE COMPARTMENT. OPERATOR SHALL CONTROL THE FUNCTIONS OF THE MANLIFT FROM THE BASKET DURING THIS TEST. EXTEND BOOM APPROZIMATELY ONE QUARTER OF FULL LENGTH AND RAISE BASKET APPROXIMATELY 15 FEET OFF THE GROUND. DEPRESS OR TILT THE SLOPE SENSOR MECHANISM LOCATED INSIDE THE CONTROL BOX. ASSURE ALL FUNCTIONS EXCEPT TRAVEL DO NOT OPERATE IN THIS CONDITION AND/OR THAT THE WARNING LIGHT LOCATED ON THE BASKET CONTROL PANEL COMES ON. SHUT OFF THE ENGINE, AGAIN DEPRESS SLOPE SENSOR MECHANISM. DEMONSTRATE THE ABILITY TO GO TO A SAFE CONDITION USING THE EMERGENCY POWER SYSTEM. WARNING LIGHT ON BASKET CONTROL PANEL WILL NOT COME ONE. TRAVEL TEST ZERO TEST WEIGHT LOAD TRAVEL THE MACHINE IN BOTH DIRECTIONS OVER A DISTANCE AT LEAST EQUAL TO THE LENGTH OF THE MACHINE, IN HIGH SPEED MODE. REPEAT STEP 1 IN LOW SPEED. IT IS THE SOLE DESGRETION OF THE GOVERNMENT TO AWARD OPTION YEARS WHICH SHALL INCLUDE THE SAME SPECIFICATIONS AND TESTING AS IN CLIN 0001 QUOTE FOR THE FOLLOWING PERIODS OF TIME ITEM 0002 OPTION YEAR ONE 01 OCTOBER 2003 THROUGH 30 SEPTEMBER 2004, ITEM 0003 OPTION YEAR TWO 01 OCTOBER 2004 THROUGH 30 SEPTEMBER 2005, ITEM 0004 OPTION YEAR FOUR 01 OCTOBER 2005 THROUGH 30 SEPTEMBER 2006. THE FUNCTIONAL EQUIPMENT IS REQUIRED F.O.B. DESTINATION BY 01 OCTOBER 2002. INSPECTION AND ACCEPTANCE WILL BE AT DESTINATION. PLACE OF DELIVERY IS NRMD, NAVAL SUBMARINE BASE NLON, GROTON, CT. 06349. QUOTATION SHALL INCLUDE AS A MINIMUM: UNIT PRICE FOB DESTINATION, A POINT OF CONTACT NAME AND PHONE NUMBER, PAYMENT TERMS, AND ALL PROVISION INFORMATION CALLED FOR IN 52.2123-3. THE FOLLOWING FAR PROVISIONS AND CLAUSES ARE APPLICABLE TO THIS PROCUREMENT: 52.212-1 INSTRUCTIONS TO OFFERORS-COMMERCIAL ITEMS. 52.212-3 OFFEROR REPRESENTATIONS AND CERTIFICATIONS-COMMERCIAL ITEMS. 52.212-4 CONTRACT TERMS AND CONDITIONS-COMMERCIAL ITEMS. 52.212-5 CONTRACT TERMS AND CONDITIONS REQUIRED TO IMPLEMENT STATUES OR EXECUTIVE ORDERS-COMMERCIAL ITEMS (CLAUSES CHECKED UNDER 52.212-5 (ALTI) ARE 52.222-21, 52.222-26, 52.222-35, 52.222-36, 52.222-37, 52.232-33. ALL CLAUSES SHALL BE INCORPORATED BY REFERENCE IN THE RESULTATN ORDER. ADDITIONAL CONTRACT TERMS AND CONDITIONS APPLICABLE TO THIS PROCUREMENT ARE DFAR 252.212-7001 CONTRACT TERMS AND CONDITIONS REQUIRED TO IMPLEMENT STATUES OR EXECUTIVE ORDERS APPLICABLE TO DEFENSE ACQUISITIONS OF COMMERCIAL ITEMS (NO CLAUSES CHECKED) 252.204-7001 COMMERCIAL AND GOVERNMENT ENTITY (CAGE) CODE, 252.204-7004 REQUIRED CENTRAL CONTRACTOR REGISTRATION, DOD WILL NO LONGER AWARD CONTRACTS TO CONTRACTORS NOT REGISTERED IN THE CENTRAL CONTRACTOR REGISTRATION (CCR) DATABASE. REGISTRATION MAY BE DONE BY ACCESSING THE CCR WEB SITE AT HTTP://WWW.CCR.GOV. A PAPER REGISTRATION FORM MAY BE OBTAINED FROM THE DD ELECTRONIC COMMERCE INFORMATION CENTER AT 800-334-3414. NO NUMBERED NOTES APPLY. THIS ANNOUNCEMENT WILL CLOSE AT 3:00P.M. CONNECTICUT TIME ON 20 SEPTEMBER 2002. ALL RESPONSIBLE BUSINESS SOURCES MAY SUBMIT A QUOTATION WHICH SHALL BE CONSIDERED BY THE AGENCY.
- Place of Performance
- Address: NAVAL SUBMARINE BASE NLON, GROTON, CT.
- Zip Code: 06349
- Country: USA
- Zip Code: 06349
- Record
- SN00166770-W 20020916/020914213739 (fbodaily.com)
- Source
-
FedBizOpps.gov Link to This Notice
(may not be valid after Archive Date)
| FSG Index | This Issue's Index | Today's FBO Daily Index Page |